1530059 Toyota Yaris & Yaris Verso Modelle 2002 - 2006 ......TOYOTA Yaris Verso from 10-2003:...

6
Page 1 / 6 -Cruise II Installation instructions for Toyota Yaris & Yaris Verso Modelle 2002 - 2006 -Cruise e -Cruise e Altendorf GmbH Telefon +49 391 7446260- www.a-a.de 1530059 Rev. 1.0

Transcript of 1530059 Toyota Yaris & Yaris Verso Modelle 2002 - 2006 ......TOYOTA Yaris Verso from 10-2003:...

Page 1: 1530059 Toyota Yaris & Yaris Verso Modelle 2002 - 2006 ......TOYOTA Yaris Verso from 10-2003: Orginal clutch switch. Only mount these wires on vehicles with manual transmission Otherwise

Page 1 / 6

-Cruise IIInstallation instructions for

Toyota Yaris & Yaris Verso Modelle 2002 - 2006

-Cruisee -Cruisee

Altendorf GmbHTelefon +49 391 7446260- www.a-a.de

1530059 Rev. 1.0

Page 2: 1530059 Toyota Yaris & Yaris Verso Modelle 2002 - 2006 ......TOYOTA Yaris Verso from 10-2003: Orginal clutch switch. Only mount these wires on vehicles with manual transmission Otherwise

1530059 Rev. 1.0

E-Cruise II

Lesen Sie die gesamte Einbauanleitung sorgsam durch, bevor Sie mit der Installation beginnen. Sie beinhaltet Informationen darüber, wie der E-Cruise fachgerecht eingebaut wird. Der E-Cruise darf nur von Fachleuten eingebaut werden, da moderne Fahrzeuge mit kostenintensiver Elektronik ausgestattet sind, welche durch unangemessenes Handeln leicht beschädigt werden kann.

Altendorf GmbH kann für keine Fehler aufgrund falscher Installation verantwortlich gemacht werden.

Kontrollieren Sie den Einbausatz auf alle vorhandenen Teile.1x Modul (1530059)1x 14-poliger Stecker (15030142 Gaspedal) Plug & Play1x 12-poliger Stecker (1530155)Kupplung,Bremse, Speed1x 3615 (Kupplungsschalter)1x Einbauanleitung

Optional LED bestellen ( )

Hinweis: Es können folgende Bedienhebel verwendet werden. (Standardbedienhebel -links/rechts Montage-) (Bedienhebel mit LED - links Montage-) (Bedienhebel Memory, 3-farb-LED & Limiter -links Montage)

Temp-LED 1539011

Temp-1533141Temp-1533124Temp-1533180

Vor der Installation

Seite 2 / 5

Wichtige Einbauhinweise:

1. Trennen Sie immer das Massekabel von der Batterie, bevor Sie mit der Installation beginnen.

2. Benutzen Sie immer die beiliegende Einbauanleitung.3. Überprüfen Sie, ob die Rev. Nummer des Aufklebers mit der Nummer der

Einbauanleitung übereinstimmt.4. Halten Sie den evtl. notwendigen Radiocode bereit.5. Suchen Sie eine geeignete Stelle für die Montage des Bedienteils und

des Moduls.6. Nicht benötigte Kabel sind zu isolieren.7. Benutzen Sie nur Multimeter bei der Messung.8. Alle Kabel sind zu löten.9. Alle Verbindungen sind von der Kabelseite aus zu betrachten.10. Führen Sie abschließend eine Probefahrt durch und testen dabei die

Funktionen des E-Cruise.

Altendorf GmbHTelefon +49 391 7446260- www.a-a.de

Falls nicht geügend Platz für denOBD Stecker vorhanden ist, trennen Sie den Stecker ab und löten Sie die Kabel.Rotes Kabel in Position 6Schwarzes Kabel in Position 1

Toyota Yaris & Yaris Verso 1.4 D-4D model 2002 - 2005

Page 3: 1530059 Toyota Yaris & Yaris Verso Modelle 2002 - 2006 ......TOYOTA Yaris Verso from 10-2003: Orginal clutch switch. Only mount these wires on vehicles with manual transmission Otherwise

Page 3 / 6

RedWhite/BrownBlue

If no ignition on Red wire in the brake connector, cut the Red wire at the edge off the breake connector,

and solder the Red wire on ignition wire.

Connector on the brake pedal

Connector on the accelerator pedal

1530059 Rev. 1.0

E-Cruise II Toyota Yaris & Yaris Verso 1.4 D-4D model 2002 - 2005

Page 4: 1530059 Toyota Yaris & Yaris Verso Modelle 2002 - 2006 ......TOYOTA Yaris Verso from 10-2003: Orginal clutch switch. Only mount these wires on vehicles with manual transmission Otherwise

Page 4 / 6

Good ground connection

Purple

Black connector on the ECU(Viewed from wire side)

Purple/White(Speed)

Black

1530059 Rev. 1.0

E-Cruise II Toyota Yaris & Yaris Verso 1.4 D-4D model 2002 - 2005

Page 5: 1530059 Toyota Yaris & Yaris Verso Modelle 2002 - 2006 ......TOYOTA Yaris Verso from 10-2003: Orginal clutch switch. Only mount these wires on vehicles with manual transmission Otherwise

Page 5 / 6

Red

WhiteYellow

TOYOTA Yaris & Yaris Verso:

enclosed clutch switch. The clutch switch must be placed on the same level as the pedel stop

The Pedal stop is measured and replaced by the

Red/White(+12V activated)

Connector on clutch pedal(Viewed from wire side)

TOYOTA Yaris Verso from 10-2003:Orginal clutch switch.

Only mount these wires onvehicles with manual transmission

Otherwise cut off, and isulate

Only use one of the solutions.

Aftermarket clutch switch

1530059 Rev. 1.0

E-Cruise II Toyota Yaris & Yaris Verso 1.4 D-4D model 2002 - 2005

Page 6: 1530059 Toyota Yaris & Yaris Verso Modelle 2002 - 2006 ......TOYOTA Yaris Verso from 10-2003: Orginal clutch switch. Only mount these wires on vehicles with manual transmission Otherwise

Page 6 / 6

Trouble shooting guide.

Reaction to the individual tests, requires that the function is active

Test 1 - Brake function. Activate RES briefly. Test LED will flash orange 1 time.CANbus installation: (No wires mounted on the brake connector).

1. Test LED lights up Red, and changes to green when pedal is depressed.

Analog installation: (Wires mounted on the brake connector).1. If both brake wires are installed correctly, the test LED will light up green.2. Hot side of brake is defective = test LED lights up red.3. Cold side of brake is defective = test LED lights up orange.4. Both sides of brake defective = test LED flashes all 3 colors.5. When brake pedal is depressed, the test LED lights up orange.

Test 2 - Clutch function. Activate RES briefly. Test LED will flash orange 2 times.CANbus installation: (No wires mounted on the clutch connector).

1. Test LED lights up Red, and changes to green when pedal is depressed.

Analog installation: (Wires mounted on the clutch connector).1. If clutch wires are installed correctly, the test LED lights up green.2. If clutch is defective, the test LED lights up red.3. When clutch pedal is depressed, the test LED lights up red.

Test 3 - Accelerator pedal function (engine off). Activate RES briefly. Test LED will flash orange 3 times.1. The test LED will slowly flash red/green.2. Depressing the accelerator pedal will increase the freq. of the flashing.

Test 4 - VSS function (engine running). Activate RES briefly. Test LED will flash orange 4 times.CANbus installation: (Purple wire is not connected).

1. The test LED will flash green if correct ID is received.

Analog installation: (Purple wire is connected).1. The test LED will flash green when vehicle is moved.

Test 5 - TACHO function (engine running). Activate RES briefly. Test LED will flash orange 5 times.CANbus installation: (Purple wire is not connected).

1. The test LED will flash green if correct ID is received.

Analog installation: (Purple wire is connected).1. The test LED will flash green when RPM is raised.

Test 6 - Setup to Automatic gear. Activate RES briefly. Test LED will flash orange 6 times. (This point should ONLY be performed if it is described on the front page with red text).

1. Activate and hold down the brake pedal.2. Activate SET briefly = test LED lights up red.3. Activate SET briefly again = test LED lights up orange. E-Cruise is set for automat gear.

If this function is activated by mistake. The test procedure must be entered from start.

Setup to Manual gear.1. Activate and hold down the brake pedal.2. Activate SET briefly = test LED lights up green.3. Activate SET briefly again = test LED lights up orange. E-Cruise is set for manual gear.

Put ignition on the vehicle

Within 2 seconds, press and hold the ON function

Wait until test LED lights up in RED color

Press and hold SET function

The test LED will flash in all 3 colors, provided that noinputs are activated. Otherwise the test LED will light up red.

The test LED lights up in ORANGE color

Release ON function

Release SET function

Press RES function

Within 5 seconds

Within 5 seconds

ONRESSET

ONRESSET

ONRES

SET

ONRESSET

ON

RESSET

Enable Diagnostic mode:

12

6

39

12

6

39

1530059 Rev. 1.0

E-Cruise II Toyota Yaris & Yaris Verso 1.4 D-4D model 2002 - 2005